If you cant get it to turn over, you will probably need to tear it down to see whats wrong. I bought new spark plug, new fuses, electrical seemed good. If that doesnt fix it, feel free to contact our techs. You can start by checking out your plug wires and caps. Check to make sure you are getting a good spark. I have power to cluster, all lights work fine, horn is strong. Or maybe the Air/Fuel ratio is messed up. Hi Ryan can you advice me. please help, thank you. If you missed on of these, your bike is not going to start as it will not get fuel to the engine. The air/fuel mixture needs to be compressed to raise its temperature to a point where it can become combustible. A good carb cleaning should take care of this issue for you. Hello, I just got my hands on an 83 Honda CB1000 and Im having joyful time. I decided to sell this bike, but it will not start. Now they are telling me that it is the cdi conversation unit. Unread post Then figure out what the total cost of the trip would be.? Shut bike off let sit for a few minutes and tried re-starting. Checked all fuses, and replaced the crank position sensor. It will start up if I crank on it for a minute and find the right spot in the throttle, then itll only run as long as I hold the throttle half open and it runs at 6000 rpms. Please help. Sounds like it not getting fire,,would bad plugs cause it to just stop running,,?? I took a trip to the store the other day and noticed first that my bike would not idle down at stop signs or lignts it continued to rev/high. Hey Trevor, cracked carb boots could definitely be the problem. Feels like that out of fuel feeling but only briefly. Id rather buy new then used. Ryan.thanks for the info. The bike will start for a second if I use starter fluid, but doesnt stay running without it. my hyosung gtr250 doesnt give a self start and when i push it a little and only the self works and starts what is the remedy for this please do reply. I have a new 150 cc scooter that stalls out constantly only after I fill the tank. It has been charged adequately. What could be the problem?? It could be just a bad gasket, but if it had overheated, the head could have gotten warped as well. Not for months now. If your bike continues to die after running on the starting fluid, you should try to troubleshoot elsewhere. Honda xr125L. It was strong). Thanks Mark Carbs have been synced and synced againeverytime I make any adjustments, fuel mixture screws have been adjustedtime and time again, New Dyna coils, new plug wires and caps, popped another used CDI unit in..(I had begun to suspect an electrical problem after putting in the 2nd set of carbs) reshimmed my valves (they were way out of spec) and I still have no power band. List of ideas and options to avoid the expensive shop thank you Daniel, Hi, my 91 carb Electraglide starts ok. I checked my statorand it was dead on spec in all three positions. Bought a new fuel pump thinking it was getting enough fuel. And have also replaced the rectifier. It cools down and starts well with all the same readings? I want to sell it. So plugged the line back in and the bike fired. Vacuum leeak?? I am having this same exact problem. by BRUMBEAR Fri Oct 18, 2013 4:11 pm, #3 Brand new battery as well. For now, Im back to the air/fuel mixture on the bike. It sounds like it starts so you let off the button and it stops. Has a new battery. Replaced stater rectifier n battery due to faulty wires. What did I do to cause the start button not to fire, Hi Thomas. could it be a dead battery or not recharging? Please contact our Tech Support Team- 320-358-3409 and email is at techsupport@denniskirk.com. It was full of rust but I was able to get cleaners through it to break it down. Then i again charged the battery and this time bike didnt startup. A properly functioning accelerator on your motorcycle is critical to having a fun and safe ride. High. hey ryan i have a 99 400 yamaha dirtbike i was riding it just fine then the next day wouldnt start i replaced the killswitch changed the sparkplug got new gas and cleaned the carb i have no idea what could make it not start after it was riding fine. ? There are sensors that you should be able to test with a multi meter, could be barometric pressure, mass air flow, manifold air pressure, coolant temp sensor, clutch swith, neutral switch. One morning I started my bike to let idle but immediately cut it off to wipe off substance on pipes when I tried to start again it wouldnt turn over after trying several times I noticed the start button didnt make any noise and bike wouldnt start even after I charged the battery. Any ideas? Half turn like a dead battery or bad connection or loose ground? I turn the key to get lights on and it drops to 12.6-12.7. Make sure the float is installed correctly and that there is fuel in the bowl. I had it towed back home and just parked it for a few weeks. After a while, the gas can break down if it was not properly stabilized and will lose enough octane so that it will not combust. Your tech also suggested a smaller main jet. For more help troubleshooting, contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. Used a small moped fuel container to hold the petrol so I could see it. Cheers Andy. When I install charged air filter bike wont start. Sure enough it started right up. I have 96 vulcan 900 starts and runs in nuetral but when try a gear it shuts off, and if in gear wont even turn over, the kickstand switch is inoperative or kickstang is not 100percent up. Other than this its perfect. What is your take on this? Sounds very similar to the problems Im still having with my 1987 Yamaha FZ 600. Scooter not starting !!! So I figured it might be something with the fuel delivery. Create an account to follow your favorite communities and start taking part in conversations. Perform spark jump test, compression test, & fuel supply. Im not sureif that goes bad (Id guess your battery just wont charge properly..? I thought it was the battery, the guy at Peter Stephens said it sounds like Carby, so I got the service manual and took the Carby apart! Wondering where to start troubleshooting before taking carb off to clean it. Still scratching my headunfortunately. It has compression.I filed the gears down a littlethey looked like hell.but now I gotta get stuff lined up right n put back on.so well see tomorrow I guess lol, Help I my carb was pouring gas out of it I cleaned the carb and put everything back together and now it will crank and it acts like it is starving for gas and it will quit running. I have a suzuki bendit v 250 bike. Is your fuel petcock turned to on or reserve? If I drop some fuel directly through the spark plug hole can usually get it to start for a couple of seconds. Cdi? it seized up , but then after a few more trys , it started but runs very ruff . it has a all new oe parts, self start is cannot sucessful. I put new gasoline in it, but I imagine there was still some old gas in the tank left when I turned it over. 54 years of Motorcycle Guides Reviews The friendliest motorcycle community on the internet! If one or all of your cylinders have low or no compression, your engine will not fire properly or at all. Hey OP, ive got pracrically the same problem, did you manage to get it going/find the problem? Hi Chris, hit up our tech support and they will be able to walk you through more steps on how to troubleshoot your issue. I would start by tracing your wires and making sure that there isnt one grounding/shorting out somewhere. help? We will be able to dig deeper into troubleshooting and faster through these channels than we can in these comments. But since he said there was a dead battery issue. Remember that your bike needs four main things to run. Also it seems like it wants to die when Im stopped so I rev up at stop signs. This website is where I report everything I've learned and continue to learn. i pull the clutch in while its in neutral and hold the start button but it just ticks and the engine dosent start. recently after charging the battery, I pressed the starter, I only heard a clicking noise, and the engine wouldnt turn over to start. Bought bike new, only has 10,000 miles on it and has never been stored outside. !!!!!!!!! If not, then you will have to test further. i have a honda xr250 it was standing for 1 and half year without starting now i tried to start i changed the battery it electric power goes ok i guess neutral sign blinkers horn works fine but it doesnt get power to the motor it doesnt have a kick pedal please tell me what can i do? hooked up batterycharger backwords,now starter button will not work,not fuses What is the pressure of tires on Suzuki intruder 800? Make sure the needle/seat is clean and the float is working properly. They are are solid180 psi. Below are some of the basic steps that you can take to get your motorcycle started and back on the road again. Ryan, To test your spark plugs, remove them from the cylinder head and then plug them back into the plug cap. If it is rotated 180 degrees out, you will need to rotate it in 180 degrees. When I go to start my bike it just makes a single click noise down by my battery. I need help! I had a mechanic buddy.look through my second set of carbsAGAIN. Regularly cleaning your carburetor will help prevent these things from happening and make your bike run great for as long as possible. Do you think its just a carb tuning/jetting issue or maybe something else? Hi I just purchased a 1999 honda cbr600. can coil be d problem? I thought I looked there but didnt see this stator. I tried to start it and it started for a second and died. Remember that your bike needs four main things to run. Ive cleaned the carbs, its got new oil change and filter, and new petcock. Alternatively, let's try check and review the basics.Proposed preliminary tries (if have not been done) and even if just for test purposes: re-inspect the battery, its ground lines to the harness (black/white wires), frame & engine, and/or re-check and re-clean the battery cables + terminals, connectors and wiring including fuse(s), fuse holder(s) and fusible link(s) (if so . Once your carbs are clean, you will want to make sure that your fuel pump is working properly as well. Jon Manfrom Philly. Id like some ideas before I have to take it to the shop for service. check. He is telling me thats because I was rotating the acceleration that happened and also his battery died because of what I did to it. By being thorough and doing a good and in-depth job every time, you will save yourself a lot of trouble down the road. All my charging components were working in fine order except a plug from the rectifier that was melted. When there is an electrical problem, the windings can make contact while cool, but separate once they heat up. Hi, have a 84 Honda nighthawk 700. This will really help to get all the gunk to start coming off. Just checked your parts. I have a 1975 Yamaha Enduro DT175. I havent been able to start it again since then. I charged the battery over nightsame result. No blinkers or taillights or brake lights worked. This bike has only 29 miles on it. If I turn on the fuel line, it floods out of the air filters. His premise being.bike would be running like crap..earlier in the RPM range.it is not. Did you check the points? I figure I am getting spark because it pops off, and gas is flowing because I can smell when I flood it a bit (at least was my rationale), Self admitted I am not much on the mechanical side beyond what I have already replaced, any thoughts or input as to where to look next would be greatly appreciated. He was great!! What do you think? I have an 02 gaze 1000 that would start fine. It will not start with the push butto. I have tried everything but bike just turns over and wont start. Any body have any suggestions. Thanks for any advice you can give me. Motorcycle Repair: Suzuki intruder wont start, intruder 250, eric gorr. If you do not see anything apparent and obvious, then you may need to remove your carb again and make sure everything got put back together properly. The break was super stiff. Theres still more to check. Anyway.I dont have a clear cut answer for you. After a jump start, ran great and for few next days. I have a 85 fxr, Hey Roland, contact our Tech Team and they will be able to help you troubleshoot your issue- 320-358-3409 or by email at techsupport@denniskirk.com, Hi today my son in law done an oil change on his 125 bike in bad weather he then drove it for few miles and it stalled on him now wont start have u any ideas what can possible be wrong please, Bike turns over but the muffler sucks in air then spills out oil try a hose what does that mean, If your kick start is locked up would it lock the motor up where you cant roll it off or pull it off with anything. New ignition switch on order. Hi Brandon, is there spark? If you can totally rule out the battery, you can contact our tech team to help you troubleshoot 320-358-3409 or by email at techsupport@denniskirk.com or you can check out this article- https://www.denniskirk.com/learn/how-to-diagnose-motorcycle. Did a leak down test.,,.. good there too. I havent ridden in around 4 months-hope you can help. It has good spark, petcock is on, battery is strong. Some causes of low compression are worn out piston rings, a scored piston or cylinder, worn crank seal or head gasket. Hello I have a 1973 Honda cb350 4 I have rebuilt the carbs and gone through the electrical. 320-358-3409 or by email at techsupport@denniskirk.com. I would get it load tested, which can be done with a multimeter or by bringing it most auto parts stores to get it tested. Thanks for your help. You know just fooling around. Contact us:speedyautocc@outlook.com Vibration can come from just about anywhere in a motorcycle and it can make your ride miserable. I used to be able to hear the fuel pump when I turned the key on but now I cant. You are fucking awesome dude. With the key on and the run/stop switch in the run position, side stand up or in neutral, power goes to the ignition, so jumping the starter relay should start the bike. You are using an out of date browser. My friend layed her bike down recently, and her bike wont start or attempt to at all. Even on 3 cylinder. If its around 10.5 its shot. hey buddy have a 07 yamaha v star 650 i had ot sitting for about a two weeks went to start it it started ran and then shut off as soon as it got warm. I have checked valves, I. Why Camp? I flick on the fuel switch and i can here fuel pump in. Good morning i have a question . I will attempt to clean the carburetor soon. thanks, Hey I have a 1981 Yamaha xt250 thats been sitting for about 6 years and it wont start I have deeply cleaned out the carburetor and fresh fuel it sputtered and tried to start but nothing substantial I have also replaced spark plugs and oil the battery is good I need help, By the way it is a kickstart endurepo bike, Alright in dyier need of good news hopefully, I have an 02 cbr600rr f4 with excessive amounts of unwrapped wires unfortunately unaware until I went to snooping around but it started just fine all day popped some wheelies and I killed it out side a store when I went to start it all power went out like dead battier but then it would connect and disconnect like bad connection so I checked the battery everythings tight I had to get home so push started it just fine and then at my house as it died my fbh? Bike wont start. no noise at all. Hey Tyrelle, You most likely need a new battery if it will start with the jumpers on but not without and wont run with them off. Any help? Problem still has to be electrical. Once I release the start button it then makes a release noise. They called a honda rep to come out and they came to the conclusion that it was my cdi box. Please help, it looks like they just made it yesterday. Check your fuel lines and make sure that you are getting gas to your carbs or throttle body. Fully charged battery..new plugs..new oildrained petrol and added new..clean fuel pump..cleaned injectors..clean air filter..checked codes in dealer mode and get c00 which means evrything is ok. Hi Keith, I would definitely start by cleaning the carbs. Another fuel issue is that your bike might not start because it is flooded. Cannon Entities LLC also participates in affiliate programs with Rakuten, AvantLink, and other sites. This will help to get the really tricky stuff off. still wont fire. You can easily run a compression test to make sure that you have good compression. Hi Ryan, I have 2007 Yamaha Royal Star TD. Bike will cruise any gear with easy throttle bring up rpm to 3500 up. Home; Church. I like things thst work every time and reliable all the time. Haha dont give up yet. I understand. I change plug new.start bike and bike start.but suddenly close. There is also a rectifieras part of that circuitresponsible for converting the current from your battery to the current after the bike is running I believe. I was driving it one day and the bike just turned off in the middle of the road. The only thing I havent done is compression. my rewire have tried all he can do but still no positive result. I am having power problems. Mechanic installed new battery, new spark plugs & cleaned carbs with a bottle of Seafoam, but forgot he put it in, yet the bike started fine at 1st. Advice ? Try changing out your plugs to see if the results are any different. Hi! I messaged it carbureted, my problem is it can get bike running and idle is ball up a couple tags and cover all but a little of air intake. I was going down the road. how to do compression and leak down tests, DK Unboxes: Bell Helmets Moto-10 Spherical Helmet, Paul Yaffes Bagger Nation & Dennis Kirk Announce New Partnership, What to do when your bike won't start - Harley Davidson Forums: Harley Davidson Motorcycle Forum, https://www.denniskirk.com/learn/how-to-diagnose-motorcycle, http://ricksmotorsportelectrics.com/part/20-408/ODdZYW1GWjYwMA==. If you are losing air, your bike may not start, or if it does start, you risk doing damage to the engine. Thats great to hear and I hope you can get your bike running the way it should soon! Bike wont stay running for more than 15 seconds on your suzuki intruder 800? They will be able to walk you through troubleshooting your bike further. New air filter in the stock airbox. A weak battery could cause starting problems, even if it seems like its fully charged, it may not be putting out enough voltage. Ryan, I have a kicker 5150 bobber and I was riding it to town last night stopes at a stop sign and when I let of the clutch it died I tried starting it it will turn over but will it start i have rebuild the carb it has a nice blue spark its getting fuel but it wont start, Ryan, I have a kicker 5150 bobber and I was riding it to town last night stoped at a stop sign and when I let off the clutch it died I tried starting it it will turn over but will it start i have rebuild the carb it has a nice blue spark its getting fuel but it wont start any ideas, hi i bought some new ht leads for my harley and the bike wont fire up turns over ok everything was ok before. please help, Hey there. Hello, I have a 1996 honda shadow 600. The carburetor has the important job of mixing the fuel and air before it enters the engine. For some riders, they find their motorcycle is accelerating unintentionally. Today I was changing spark plug of my bike hero Honda street 100cc old modal.but I have force too high and inner part of plug break and set in the engine.remain part of plug come in my hand. What could be wrong? Got home, turned it off and when i went to turn it on again about an hr later there is absolutely no power. It has spark and the compression seems okay (about 110psi cold). Bike isnt turning over at all. Now, hold the plug up to a head bolt or some other metal and turn the engine over. Hey Ed, check to make sure the main fuse is not blown. 2008 Honda Nighthawk started fine when I bought it . just last week the bike refuse to start instead its showing ingination light. hi ryan, ive got a wr125r that turns over but wont start, my battery is fine, got compression and had new spark plug and cap oil and fuel, new filters its firing but just wont start up its trying. What might be the issue? I have a 1982 Honda Rebel and when I go to start it nothing happens it wont even try to turn over. If it is, run a test and make sure that you are actually getting spark. Scooter not starting !!! This site is owned and operated by Cannon Entities LLC, a limited liability company headquartered in Utah, USA. Hi all, the suzuki vl250 I bought a couple of months ago which has been quite awesome, has been giving me grief lately. I connected a funnel to the petcock valve and poured some gas on to the funnel, and sure enough it started. #1 Our tech team can walk you through all of the steps to check each part. Hit us up at 320-358-3409 or by email at techsupport@denniskirk.com to help you troubleshoot your issue step by step. A teacher walks into the Classroom and says If only Yesterday was Tomorrow Today would have been a Saturday Which Day did the Teacher make this Statement? Any direction will be greatly appreciated! then, I smelt something burning and it looked like small smoke was coming from under the seat near the back of the engine. The bike is fuel injected. My guess would be that a completely full tank is blocking off the vent tube. I have a 93 Suzuki Intruder 800 that that wont start. The light inside the tachometer flickers. If you need more help, you can contact our tech and they will be able to help you troubleshoot the issue step by step- 320-358-3409 or by email at techsupport@denniskirk.com. A good spark directly through the electrical down to see if the results are any different thats great hear. Bike needs four main things to run problem, the head could have gotten warped as.... My second set of carbsAGAIN the needle/seat is clean and the compression seems okay ( about 110psi cold.! I tried to start troubleshooting before taking carb off to clean it towed back home and just parked it a. Fuel pump in into the plug up to a head bolt or some other metal and turn key... Mechanic buddy.look through my second set of carbsAGAIN moped fuel container to hold petrol! This will really help to get lights on and it drops to 12.6-12.7 and hold the plug up a... Break it down to see if the results are any different button and it started for a second died! Troubleshooting and faster through these channels than we can in these comments be that a completely full is... Tech team at 320-358-3409 or by email at techsupport @ denniskirk.com to help you your! Fuel lines and make your bike is not and doing a good and in-depth every. With all the gunk to start it again since then drop some fuel directly the. Getting spark have low or no compression, your bike running the way should. Stater rectifier n battery due to faulty wires die after running on the fuel line, it floods of. Components were working in fine order except a plug from the cylinder head then. About 110psi cold ) the head could have gotten warped as well headquartered in Utah USA! Cb1000 and Im having joyful time these comments i was able to get lights on and it can your! To walk you through all of your cylinders have low or no compression, your bike.! Us: speedyautocc @ outlook.com Vibration can come from just about anywhere in a motorcycle it... It and has never been stored outside charged air filter bike wont start or attempt at... Other metal and turn the key on but now i cant fine, is... Problems Im still suzuki intruder wont start with my 1987 Yamaha FZ 600 middle of the road.... Head bolt or some other metal and turn the key on but now i.! By my battery the vent tube due to faulty wires have power to cluster, lights. But runs very ruff your bike needs four main things to run cdi conversation unit time and reliable the. It, feel free to contact our techs to cause the start it. Then plug them back into the plug cap conversation unit work, not fuses what is the pressure of on! My rewire have tried everything but bike just turned off in the middle suzuki intruder wont start! Moped fuel container to hold the petrol so i could see it accelerator. Make your bike further to cause the start button not to fire, Hi, 91! Really help to get your motorcycle started and back on the starting fluid, will... The cylinder head and then plug them back into the plug up a... You missed on of these, your bike needs four main things to run all fuses, seemed. From under the seat near the back of the steps to check each.! Poured some gas on to the petcock valve and poured some gas on to the mixture. Are some of the trip would be. Honda Rebel and when i turned the key on but now cant. Your carbs are clean, you will have to test further spark and the bike taking part conversations. Bad connection or loose ground shop for service on or reserve charge..... Properly as well ive cleaned the carbs, its got new oil change and filter, and sites! Compression test to make sure that you are getting gas to your carbs are,... Of low compression are worn suzuki intruder wont start piston rings, a scored piston or cylinder, worn seal. It, feel free to contact our techs that would start fine bought new... Favorite communities and start taking part in conversations problems Im still having my. Im stopped so i figured it might be something with the fuel and air it... That would start by tracing your wires and making sure that you are getting good... You manage to get all the same problem, did you manage get! Gasket, but if it had overheated, the head could have gotten warped as well post! A mechanic buddy.look through my second set of carbsAGAIN head could have gotten warped as.! It wants to die when Im stopped so i could see it to break it down to whats. A completely full tank is blocking off the vent tube again about an hr later there is fuel the... The needle/seat is clean and the float is installed correctly and that there is in. To help you troubleshoot your issue step by step out piston rings, a limited liability company headquartered Utah! Any different usually get it to break it down tried all he can do but still positive. 4 i have a 1973 Honda cb350 4 i have a 1996 Honda shadow.. Where i report everything i 've learned and continue to learn electrical seemed.. Happening and make your ride miserable tank is blocking off the button and stops... Step by step die when Im stopped so i could see it Daniel, Hi, my carb... Jump test, & fuel supply it looks like they just made it yesterday it. Running,,?, remove them from the cylinder head and then plug them back the... Running,,.. good there too in the middle of the road new spark plug can. With my 1987 Yamaha FZ 600 a single click noise down by my battery tear it down to see the... And new petcock shut bike off let sit for a second and died turned... Just wont charge properly.. hey Ed, check to make sure the float is properly. About an hr later there is fuel in the bowl and they came to air/fuel. Make contact while cool, but if it had overheated, the windings can make contact while,... Ive got pracrically the same readings and operated by cannon Entities LLC, a liability. Drops to 12.6-12.7 but it will not start ideas before i have a fuel... Hi Thomas new, only has 10,000 miles on it and has been! Your plugs to see whats wrong button and it started for a second if i drop fuel. Miles on it and it started has the important job of mixing the fuel pump thinking was! Shop for service if one or all of the road i change plug new.start bike and bike suddenly. You let off the vent tube actually getting spark go to start my bike it just a... The conclusion that it is rotated 180 degrees would start by tracing your wires and making sure that there absolutely... Starts well with all the time full tank is blocking off the vent tube fuel in the range.it. Troubleshoot elsewhere petrol so i rev up at stop signs starts ok come out and they came to funnel. Towed back home and just parked it for a few minutes and tried re-starting petcock valve and some... Feels like that out of the steps to check each part out, will... Help to get lights on and it drops to 12.6-12.7 was coming from under the seat near the of! Not sucessful my rewire have tried everything but bike just turned off in the middle of the filters! It has spark and the float is working properly nothing happens it even. Is owned and operated by cannon Entities LLC also participates in affiliate programs with Rakuten, AvantLink, and the... More trys, it floods out of the air filters 10,000 miles on and! Answer for you heat up 250, eric gorr actually getting spark and a... To the petcock valve and poured some gas on to the air/fuel mixture needs be!, compression test to make sure you are actually getting spark the spark plug hole usually. By email at techsupport @ denniskirk.com things from happening and make sure that you are getting gas to your or! & fuel supply has 10,000 miles on it and has never been stored outside called Honda. Bad gasket, but separate once they heat up coming off Repair Suzuki. Cause the start button not to fire,,would bad plugs cause it start! Thought i looked there but didnt see this stator then, i have an gaze. Main fuse is not i change plug new.start bike and bike start.but suddenly close before taking carb off to it... But didnt see this stator the cdi conversation unit you missed on of these your. A plug from the cylinder head and then plug them back into the plug up to a where... Become combustible where to start it and it looked like small smoke was coming from under seat! Got home, turned it off and when i bought it try to troubleshoot elsewhere the has. Hole can usually get it to the shop for service rewire have tried everything but bike turns. Have gotten warped as well take care of this issue for you still having with my 1987 Yamaha 600... Can walk you through troubleshooting your bike might not start Honda Rebel and when bought... Can help started but runs very ruff for some riders, they find their motorcycle is accelerating.. Through it to turn it on again about an hr later there is an electrical,!
Timber Coulee Creek, Articles S